We really like to visit the Polaris UTV. Unfortunately we have Polaris RZR, RZR-S, and built the Ranger XP with a reliable fuel pump. In fact, the fuel pump is one of the main problems we see in our service and store performance. The symptoms are usually experienced when the pump fails the poor results in higher speeds, a loss of top speed and poor acceleration. This is probably the most fun, Polaris, much less to drive, but more importantly, a problem with the fuel pump the fuel, the engine damage that is not devastating enough. If the engine is not the fuel that runs thin.
This generates heat, which can cause detonation in the combustion chamber. The worst (and I have often seen) is that the heat melted a hole in the piston. This is what happens. After a few to wear the pump and the fall of the factory setting of 39 PSI, a 30 year low. If the speed is slower than simply without fuel. To test, connect the installation of a pressure gauge on the tank. You can buy these at NAPA or Pep Boys. You must run the engine when the test several times because the pressure will be very slow, but not at high speed.
To replace the pump with the fuel pump OEM will spend about $ 600. The high price because it completely only with the installation of the fuel tank. Fortunately, you can buy a replacement fuel pump that works in most vehicles SXS Polaris. Replacement pumps come with instructions on color and contain everything needed for installation. In general, it can be installed in about 30 minutes with simple hand tools. The pump is connected very well with no wiring required.
If you have bad performance with Polaris Ranger RZR, or it may be the problem. Look at your ISP, when the fuel pump and get an alternative fuel. You have to have your Polaris a good time. You can now start your UTV back and enjoy maximum performance again. As a side note the same problem the fuel pump is used in many Polaris ATV with fuel injection. If you have a Polaris ATV, the symptoms are similar to their own, just follow the same procedure to test the ISP. Pump parts are also available for Polaris sportsman.
Alba Hove succeeds Patrick Racing, a service center and high-performance motorcycles, ATV and UTV in Santee, California. The company has 20 years experience working with the factory race teams for the major manufacturers and also supervises the preparation of the race for the race SCORE works team, the team of Matlock.
No comments:
Post a Comment